DPF Servicing Solutions

And DPF Removal (Race)

MARINE

Finally, a non factory Diesel Particulate Filter (DPF) Solution is here! DPF Cleaning, Exchange, Aftermarket, Removal (Race only) Solutions and Replacement Service.

NOTE TO NSW VEHICLE OWNERS:

NSW vehicle owners need to be aware that you must not use a vehicle on any road or roads related area in NSW if any anti pollution device has been removed unless the vehicle is being used in motor racing or off road motor sports. Other Countries, States and Territories may have similar restrictions. Check with your Country, State or Territory regarding your rights.

NOTE TO VICTORIAN VEHICLE OWNERS:

Victorian Environment Protection Regulations: A person must not, without just cause, alter, replace or modify the engine or the exhaust system or fuel system of any motor vehicle in a way that - (a) departs from the manufacturer's design: or (b) increases the rate of discharge of any of the constituent parts of emissions or (where applicable) defeats the intended upward discharge or dispersion of the emissions.

DPF disasters and engine degradation due to engine oil dilution or excessive back pressure is a very common issue with modern diesels fitted with a Diesel Particulate Filter. For many years the only option for DPF equipped vehicles experiencing problems (ie DPF warning light on the dashboard of the car) was to replace the old blocked DPF with a Factory unit, costing upwards of $6000.

1 Option: Our DPF Delete solution (Race use only) COMPLETELY eliminates the problem so that the DPF never haunts you again. Additionally, to take advantage of the freer flowing exhaust system that our solution affords, we can now tune back the power and the economy that was necessarily removed when the manufacturer adopted the DPF system on these vehicles.

Another benefit, whilst we are reprogramming the tune file, is to disable other performance robbing, maintenance demanding systems such as the Exhaust Gas Re-circulation System (EGR).

Lastly, another problem solved is the Diesel Particulate Filter systems engine engine oil contamination that occurs. We have seen many vehicles coming in with more diesel in the oil sump than oil!!

FAILED-DPF2-r6b010imneln4nbry4r01uyicofqpema447eqj1vaw.jpg

Just take a look at where some manufacturers place the “X” indicator mark on the oil dipstick. It is often DOUBLE the oil quantity from the “full” mark!

This means the manufacturer allows you to drive the vehicle with much less quality engine oil (lubrication quality) than what is actually needed to keep your engine running with minimal wear and tear. This oil contamination will ultimately kill your engine.

Just take a look at where some manufacturers place the “X” indicator mark on the oil dipstick. It is often DOUBLE the oil quantity from the “full” mark! (see pic below)

This means the manufacturer allows you to drive the vehicle with much less quality engine oil (lubrication quality) than what is actually needed to keep your engine running with minimal wear and tear. This oil contamination will ultimately kill your engine. We recommend to have the oil pick up checked at time of the DPF Service.

WHAT DPF SERVICES DO WE PROVIDE?

We can confidently provide a COMPLETE DPF removal solution (Off-road Use) by which we switch off the DPF configurations in the factory ECU and effectively eliminate the DPF from the vehicle both physically and electronically with zero Check Engine Lights appearing on the dash. Your car won’t fall into limp home mode and you’ll get both a performance increase and a fuel saving as well!

If you have had this type of scare with your DPF equipped race/off-road vehicle, we now introduce this solution to you. The benefits of having dpf removal service are:

Increase in performance,
Smoother acceleration.
Less flat spots.
No more Low Ash Oil requirement which means you can change the engine oil using regular low cost oil. This alone will save you $ over the years.
Lower Exhaust Gas Temps (EGTs)
No DPF engine oil contamination
No dangerous limp modes